Find Variety Soap Noodles from Beauty and Personal Care,we are Soap Noodles 80-20 Supplier Located in Pakistan
Soap Noodles 80:20 = blend ratio of 40% Refined Palm Oil, 40% Refined Palm Stearin and 20% Palm Kernel Oil. These noodles are vegetable based – no tallow.
These noodles have undergone the saponification process to create this moisturizing base. Soap noodles are a very good alternative for those who are afraid to use sodium hydroxide (lye) to make soap. Our tester recommends the following methods:
Double boiler/crock pot: Per our tester, this is the best method to use. Heat soap noodles in a double boiler or crock pot with closed lid – again, approximately 1 cup of liquid with 1 lb. of soap noodles. Heavy cream/heavy whipping cream is also preferred here. Every ten minutes stir/mash until heavy mashed potato consistency is reached. As above, add FO/EO/colorant/additives and scoop into molds.
Microwave heating: This method is not as highly recommended by our tester as the previously-mentioned method. Heat approximately 1 cup of liquid with 1 lb. of soap noodles on 50% microwave power, three minutes at a time, with lid on container. In between 3 minute intervals take soap out, stir/mash (manual potato masher works well for this) until finished product is the texture of thick mashed potatoes. Add fragrance oil/essential oil/color and scoop into molds. Tester recommends using heavy cream/heavy whipping cream (NOT whipped cream!) as the liquid.
The dry out process would normally take a week to a couple of weeks at most. The soap is ready to take out of the mold after 24 hours or less (assuming too much liquid was not added) and will be dry to the touch in a day or two. To be on the safe side we suggest that you still give it a week to two weeks to be dry all the way through. The soap will be “cured” and be safe to use if you use it before that since the soap noodles themselves do not have active lye. You just don’t want to use the soap too early, as it will be too soft and it will all melt away. A longer drying time would not hurt the soap and it would avoid the mistake of accidentally using it too early.